Serie unità rifasamento automatico Series automatic power factor correction unit - LONG LIFE 4In - LONG LIFE 4In IP54 Caratteristiche Generali - Gamma di potenza: 20 200 kvar - Tensione di rete (impiego): 400 V (altre tensioni su richiesta). - Frequenza nominale: 50 Hz (60 Hz a richiesta). - Corrente di cortocircuito (1s): 8 13kA (80kA condizionati da fusibile a monte) - Altitudine: 2000 m s.l.m. - Umidità relativa: 70% max. a 20 C -Servizio: continuo. - Classe di temperatura ambiente: -5 + 40 C (su richiesta + 55 C) - Norme: CEI EN 61921 Caratteristiche Elettriche - Linea di alimentazione: Trifase + PE - Segnale Amperometrico: da TA in linea.../5a - Segnale Voltmetrico: prelevato internamente. Struttura Meccanica - La struttura di base è realizzata in lamiera di acciaio zincata bianco dello spessore di 15/10; le piastre di fissaggio dei componenti hanno spessore di 12/10. - I componenti interni sono accessibili a mezzo involucro interbloccato con il sezionatore generale. - La struttura esterna in carpenteria di lamiera d acciaio è verniciata con trattamento di pulitura, sgrassaggio, ciclo di fosfatazione, vernice dello spessore di 50 µm a base di polveri epossidiche colore RAL 7032. - Nella parte inferiore e superiore sono presenti apposite feritoie per agevolare e consentire una facile ventilazione naturale. Il grado di protezione di tali aperture è IP30 (IP54 con filtri e ventilazione forzata). General Characteristics -Power range: 20 200 kvar - Mains voltage (working voltage): 400 V (other voltages on request). - Rated frequency: 50 Hz (60 Hz on request). - Short circuit current (1s): 8 13kA (80kA fused condional) - Altitude: 2000 m a.s.l. - Relative humidity: 70% max. at 20 C -Duty: continuous. - Ambient temperature class: -5 + 40 C (on request + 55 C) - Standards: CEI EN 61921 Electrical Characteristics - Power supply line: Three-phase + ground - Relay current input signal: from CT on line.../5a - Relay voltage input signal: picked up internally. Mechanical Structure - The basic structure is made of white galvanized steel sheet with thickness 15/10; the component fastening plates have thickness 12/10. - The internal components are accessible through the shell interlocked with the main disconnecting switch. - The outer steel structural work is painted with cleaning treatment, degreasing, phosphating, 50 µm thickness paint with epoxy powder colour RAL 7032. - Special slits at the top and bottom assist natural ventilation. The protection rating of these openings is IP30 (IP54 with filters and forced ventilation). 51
Ducati 200-M Modalità d installazione - Per interno, a muro, in ambiente ventilato e non polveroso, al riparo dalla luce diretta del sole. - Ingresso cavi dall alto Sezionatore Generale - Sezionatore omnipolare, con blocco porta e del tipo a velocità indipendente da quella di manovra dell operatore. - Corrente nominale del sezionatore 1,45 volte la corrente di esercizio a 400 V. Collegamenti Interni -Cablaggi realizzati con cavi tipo N07VK. Fusibili -A valle del sezionatore sono presenti una o più terne di fusibili, posti a protezione delle batterie di condensatori. -I fusibili sono del tipo NH-00 con caratteristica GL. Contattori - Adatti al comando di carichi capacitivi, inseriti all esterno del triangolo formato dagli elementi capacitivi monofase, dotati di un blocchetto trifase di contatti anticipati per l inserzione dei dispositivi di limitazione della corrente all inserzione. - Tensione della bobina 230V, 50-60Hz. Condensatori - Elementi monofase serie MONO - LONG LIFE collegati a triangolo. - Tensione nominale 230-415V Dispositivi di protezione - Ogni batteria di condensatori é dotata di dispositivi di scarica atti a ridurre la tensione residua al di sotto del 10% della tensione nominale del condensatore in circa 30 secondi. Regolatore - Tipo REGO 5 Collaudo 100% Su ogni apparecchiatura automatica prodotta sono effettuate le seguenti prove e controlli: - Controllo visivo e dimensionale. - Controllo funzionamento meccanico. -Prova di tensione applicata verso massa sui circuiti di potenza: 3kV per 1 minuto. - Controllo funzionamento elettrico a 400V, con controllo della capacità totale delle batterie di condensatori installate sull apparecchiatura automatica. Installation - Indoors, wall-mounted, in ventilated, non-dusty environment, away from direct sunlight. -Cable inlet from top. Disconnecting Switch - Omnipolar switch with door lock, switching time independent of operator s maneuvering speed. - The rated current of the switch is 1.45 times the operating current at 400 V. Internal Connections - N07VK type cables are used for all the wiring. Fuses - One or more triads of fuses are installed downstream from the disconnecting switch to protect the capacitor banks. - The fuses are of the NH-00 GL type. Contactors - Designed for controlling capacitive loads, connected outside the delta formed by the single-phase capacitor elements, equipped with an inrush current limiting device. - Coil voltage 230V, 50-60Hz. Capacitors - Single-phase elements series MONO - LONG LIFE in delta connection. - Rated voltage 230-415V Protection devices - Each capacitor bank is equipped with discharge devices capable of reducing the residual voltage to below 10% of the rated capacitor voltage in about 30 seconds. Power control relay - Type REGO 5 Screening inspection 100% Each automatic system manufactured undergoes the following tests and inspections: -Visual and dimensional inspection. - Check on mechanical efficiency. -Insulation test, 3kV for 1 min., between phases and ground. - Check on electrical efficiency at 400V, with verification of the total capacitance of the capacitors installed in the automatic system. B = 384 (20 50kVAr) 584 (60 80kVAr) 984 (90 100kVAr) 1184 (120 160kVAr) 1384 (180 200kVAr) 52
Ducati 200-M Un - Cond = 415V Un - Cap= 415V 0035 20 18 5 5 10 27 63 400x270x400 17 0040 25 23 5 10 10 34 63 400x270x400 17 0045 35 32 5 10 20 47 80 400x270x400 18 0050 40 37 10 10 20 54 80 400x270x400 18 0055 50 46 10 20 20 67 80 400x270x400 19 0060 60 55 10 10 20 20 80 125 400x270x600 30 0065 70 65 10 20 20 20 94 125 400x270x600 35 0070 80 74 10 10 20 40 107 125 400x270x600 35 0075 90 83 10 20 20 40 121 250 400x270x1000 40 0080 100 92 10 10 20 20 40 134 250 400x270x1000 45 0085 120 111 10 10 20 40 40 161 250 400x270x1200 50 0090 140 130 20 40 40 40 188 400 400x270x1200 55 0095 160 148 20 20 40 40 40 215 400 400x270x1200 60 0100 180 167 20 40 40 40 40 241 400 400x270x1400 65 0105 200 185 20 20 40 40 80 268 400 400x270x1400 70 Un - Cond = 450V Un - Cap= 450V 0210 20 15 5 5 10 23 63 400x270x400 17 0215 25 19 5 10 10 29 63 400x270x400 17 0220 35 27 5 10 20 40 80 400x270x400 18 0225 40 31 10 10 20 46 80 400x270x400 18 0230 50 39 10 20 20 57 80 400x270x400 19 0235 60 47 10 10 20 20 68 125 400x270x600 30 0240 70 55 10 20 20 20 80 125 400x270x600 35 0245 80 63 10 10 20 40 91 125 400x270x600 35 0250 90 71 10 20 20 40 103 250 400x270x1000 40 0255 100 79 10 10 20 20 40 114 250 400x270x1000 45 0260 120 94 10 10 20 40 40 137 250 400x270x1200 50 0265 140 110 20 40 40 40 160 400 400x270x1200 55 0270 160 126 20 20 40 40 40 182 400 400x270x1200 60 0275 180 142 20 40 40 40 40 205 400 400x270x1400 65 0280 200 158 20 20 40 40 80 228 400 400x270x1400 70 53
Ducati 200-M Un - Cond = 525V Un - Cap= 525V 0310 20 11 5 5 10 17 63 400x270x400 17 0315 25 14 5 10 10 21 63 400x270x400 17 0320 35 20 5 10 20 29 80 400x270x400 18 0325 40 23 10 10 20 34 80 400x270x400 18 0330 50 29 10 20 20 42 80 400x270x400 19 0335 60 34 10 10 20 20 50 125 400x270x600 30 0340 70 40 10 20 20 20 59 125 400x270x600 35 0345 80 46 10 10 20 40 67 125 400x270x600 35 0350 90 52 10 20 20 40 75 250 400x270x1000 40 0355 100 58 10 10 20 20 40 84 250 400x270x1000 45 0360 120 69 10 10 20 40 40 101 250 400x270x1200 50 0365 140 81 20 40 40 40 117 400 400x270x1200 55 0370 160 92 20 20 40 40 40 134 400 400x270x1200 60 0375 180 104 20 40 40 40 40 151 400 400x270x1400 65 0380 200 116 20 20 40 40 80 168 400 400x270x1400 70 54
Ducati 200-M IP54 Un - Cond = 415V Un - Cap= 415V 0036 20 18 5 5 10 27 63 500x250x700 41 0041 25 23 5 10 10 34 63 500x250x700 41 0046 35 32 5 10 20 47 80 500x250x700 42 0051 40 37 10 10 20 54 80 500x250x700 42 0056 50 46 10 20 20 67 80 500x250x700 43 0061 60 55 10 10 20 20 80 125 500x250x700 54 0067 70 65 10 20 20 20 94 125 500x250x700 59 0071 80 74 10 10 20 40 107 125 500x250x700 59 0076 90 83 10 20 20 40 121 250 600x300x1000 77 0081 100 92 10 10 20 20 40 134 250 600x300x1000 82 0086 120 111 10 10 20 40 40 161 250 600x300x1000 93 0091 140 130 20 40 40 40 188 400 600x300x1000 98 0096 160 148 20 20 40 40 40 215 400 600x300x1200 109 0101 180 167 20 40 40 40 40 241 400 600x300x1400 114 0106 200 185 20 20 40 40 80 268 400 600x300x1400 119 Un - Cond = 450V Un - Cap= 450V 0211 20 15 5 5 10 23 63 500x250x700 41 0216 25 19 5 10 10 29 63 500x250x700 41 0221 35 27 5 10 20 40 80 500x250x700 42 0226 40 31 10 10 20 46 80 500x250x700 42 0231 50 39 10 20 20 57 80 500x250x700 43 0236 60 47 10 10 20 20 68 125 500x250x700 54 0241 70 55 10 20 20 20 80 125 500x250x700 59 0246 80 63 10 10 20 40 91 125 500x250x700 59 0251 90 71 10 20 20 40 103 250 600x300x1000 77 0256 100 79 10 10 20 20 40 114 250 600x300x1000 82 0261 120 94 10 10 20 40 40 137 250 600x300x1200 93 0266 140 110 20 40 40 40 160 400 600x300x1200 98 0271 160 126 20 20 40 40 40 182 400 600x300x1200 109 0276 180 142 20 40 40 40 40 205 400 600x300x1400 114 0281 200 158 20 20 40 40 80 228 400 600x300x1400 119 55
Ducati 200-M IP54 Un - Cond = 525V Un - Cap= 525V 0311 20 11 5 5 10 17 63 500x250x700 41 0316 25 14 5 10 10 21 63 500x250x700 41 0321 35 20 5 10 20 29 80 500x250x700 42 0326 40 23 10 10 20 34 80 500x250x700 42 0331 50 29 10 20 20 42 80 500x250x700 43 0336 60 34 10 10 20 20 50 125 500x250x700 54 0341 70 40 10 20 20 20 59 125 500x250x700 59 0346 80 46 10 10 20 40 67 125 500x250x700 59 0351 90 52 10 20 20 40 75 250 600x300x1000 77 0356 100 58 10 10 20 20 40 84 250 600x300x1000 82 0361 120 69 10 10 20 40 40 101 250 600x300x1200 93 0366 140 81 20 40 40 40 117 400 600x300x1200 98 0371 160 92 20 20 40 40 40 134 400 600x300x1200 109 0376 180 104 20 40 40 40 40 151 400 600x300x1400 114 0381 200 116 20 20 40 40 80 168 400 600x300x1400 119 Fissaggio a parete Wall mounting H 20 80 KVAR 90 200 KVAR 56